Radial Outflow Turbine

RADIAL-OUTFLOW-TURBINE : http://laserstatics.com/radial-outflow-turbine/index.htm

In a radial outflow turbine the organic fluid enters the disk axially in its center and expands radially through a series of stages mounted on the single disk. At the discharge of the last rotor row the flow passes through a radial diffuser and is then conveyed to the recuperator and or condensa- tion section of the system, through the discharge volute. In the early 20th century, Parsons Siemens and Ljungstrom developed the first steam based radial outflow turbines. These early model turbines required a large number of stages. For very high enthalpy drop fluids, such as steam, a single-disk/multi stage configuration was therefore deemed not suitable due to the very large diameter disk necessary to accommodate all the required stages. No further development of the radial outflow turbines oc- curred, as they were phased out for steam applications by axial turbines.

Keywords: Exergy, radial outflow turbine, ORC, geothermal binary power plant, Bagnore, RADIAL OUTFLOW TURBINE, LOSSES, INCIDENCE, Volute, mixed flow turbine, performance, flow angle, efficiency, finite volume method, ANSYS-C

Summary of Abstracts:

The Geothermal Radial Outflow Turbine: An innovative turbine configuration for geothermal applica- tions was developed by the Italian turbine manufacturer EXERGY. The technology, known as the organic radial outflow turbine was designed, engineered, manufactured and tested in Italy. A 1 MWe geothermal organic Rankine cycle (ORC) equipped with the EXERGY radial outflow turbine has been in operation since early 2013. The radial outflow turbine is a new type of turbine that have the potential to increase the geothermal binary power plants ef- ficiency by increasing the turbine efficiency. The operational results has been positive and demonstrates the viability of the technology and the possibility to develop it for bigger sizes.

Preliminary Design and Off-Design Analysis of a Radial Outflow Turbine for Organic Rankine Cycles: Recently, the advantages of radial outflow turbines have been outstanding in various operating conditions of the organic Rankine cycle. However, there are only a few studies of such turbines, and information on the design procedure is insufficient. The turbine target performance could be achieved by fine-tuning the blade angle of the nozzle exit. In addition, performance evaluation of the turbine against off-design conditions was performed. Ranges of velocity ratio, loading coefficient, and flow coefficient that can expect high efficiency were proposed through the off-design analysis of the turbine.

Study on applicability of radial-outflow turbine type for 3 MW WHR organic Rankine cycle: The article presents the results of study on the reasonability of using radial-outflow turbines in ORC. Peculiarities of radial-outflow turbine design utilizing modern design technologies and application to ORC was considered in the first part of the paper. For this particular cycle design, turbines of radial-outflow type were chosen. Their application enables the increase of mechanical output power by 11 percent compared to original radial-inflow turbines.

LOSS GENERATION IN RADIAL OUTFLOW STEAM TURBINE CASCADES: Small high-speed technology based radial outflow steam turbines are characterised by ultra-low aspect ratios, which can lead to rapidly growing secondary losses. The prelimi- nary evaluation of turbine performance is usually based on axial turbine loss predictions, which can be a source of error. The main objectives of this work are to find out how the losses are generated in radial outflow turbines when the aspect ratio is markedly below unity and how accurately axial turbine loss models can predict the trends. To achieve these objectives, a radial outflow turbine cascade having a blade shape and aspect ratios comparable with a prototype machine is examined. As a result of the study, it is suggested that for the examined radial outflow cascade the axial turbine loss correlations can predict the trends reasonably well. The rapidly increasing secondary losses are connected to the merging of secondary structures and also incidence at off-design.

PRELIMINARY DESIGN OF RADIAL-INFLOW TURBINES FOR ORGANIC RANKINE CYCLE POWER SYSTEMS CONSIDERING PERFORMANCE AND MANUFACTURABILITY ASPECTS: In order to make organic Rankine cycle power systems economically feasible, it is essential to find a reasonable trade-off between the performance and the initial cost of system. In order to show its relevance in a practical application, the method is applied to two radial-inflow turbines cases: a state-of-the-art turbine using air and a turbine using the working fluid Novec 649 for a heat recovery application. The results indicate that there exists a trade-off between turbine performance and manufacturability, and that it is possible to develop turbine solutions with similar values of efficiency with improved manufacturability indicator by up to 14 to 15 percent.

DESIGN AND FLOW ANALYSIS OF RADIAL AND MIXED FLOW TURBINE VOLUTES: Radial and mixed flow turbines which are an important component of a turbocharger consist essentially of a volute, a rotor and a diffuser. Vaneless volute turbines, which have reasonable performance and low cost, are the most used in turbochargers for automotive engines. Care has to be done in the design of the volute, whose function is to convert a part of the engine exhaust gas energy into kinetic energy and direct the flow towards the rotor inlet at an appropriate flow angle with reduced losses.

An Exploration of Radial Flow on a Rotating Blade in Retreating Blade Stall: The nature of radial flow during retreating blade stall on a two-bladed teetering rotor with cyclic pitch variation is investigated using laser sheet visualization and particle image velocimetry in a low-speed wind tunnel. The velocity field above the retreating blade at 270◦ azimuth shows the expected development of a radially directed jet layer close to the blade surface in the otherwise separated flow region. This jet is observed to break up into discrete structures, limiting the spanwise growth of the radial velocity in the jet layer. The discrete structures are shown to derive their vorticity from the “radial jet” layer near the surface, rather than from the freestream at the edge of the separated region. The separation line determined using velocity data shows the expected spanwise variation. The results of this study are also correlated in a limited range of extrapolation to the phenomena encountered on a full-scale horizontal axis wind turbine in yaw.

PDF Source: 1033619.pdf | The Geothermal Radial Outflow Turbine

PDF Source: 10kw-neon-turbo-brayton-refrigerator.pdf | turbine-compressor 10 kW class neon turbo-Brayton refrigerator

PDF Source: 1180.pdf | Design of Radial Inflow and Mixed Flow Turbines 1971

PDF Source: 1687814020921663.pdf | ORC analysis of radial inflow turbine and R245fa

PDF Source: 19720005135.pdf | RECENT RADIAL TURBINE RESEARCH AT NASA Lewis

PDF Source: 19800008223.pdf | Radial Outflow Turbine for Solar Steam Rankine Engines

PDF Source: 19860000550.pdf | 3-D Inviscid Analysis of Radial Turbine Flow

PDF Source: 19960003236.pdf | Aerodynamic Radial Inflow Turbine Rotors

PDF Source: 3422446.pdf | NEON CRYOGENIC TURBO-EXPANDER WITH MAGNETIC BEARINGS

PDF Source: 4707099.pdf | Thermodynamic design of 10 kW Brayton cryocooler for HTS cable

PDF Source: 5138830.pdf | Radial turbine preliminary design and performance prediction

PDF Source: a242473.pdf | NASA Low-Speed Centrifugal Compressor for 3-D Viscous Code

PDF Source: Al_Jubori_et_al_New_performance_Cleaner_Production_2017.pdf | turbine configuration for low-power organic Rankine cycle

PDF Source: Applicability-ROT-for-3-MW-Waste-Heat-Recovery-Organic-Rankine-Cycles.pdf | radial-outflow turbine type for 3 MW WHR organic Rankine cycle

PDF Source: applsci-08-02038.pdf | Design and Optimization Approach for Radial Inflow Turbines

PDF Source: automotive-radial-turbine.pdf | Automotive Radial Turbine Expander Design WHR

PDF Source: BROCHURE-exergy.pdf | GREEN POWER THROUGH INNOVATION

PDF Source: Cirincione_colostate_0053N_10857.pdf | ORC WASTE HEAT RECOVERY SYSTEM WITH A TESLA-HYBRID TURBINE

PDF Source: design-flow-analysis-radial-turbines.pdf | ANALYSIS OF RADIAL AND MIXED FLOW TURBINE VOLUTES

PDF Source: design-radial-inflow-turbine-for-orc.pdf | RADIAL-INFLOW TURBINES FOR ORGANIC RANKINE CYCLE POWER

PDF Source: Design_Analysis-radial-outflow-turbine.pdf | Analysis of a Radial Outflow Turbine for Organic Rankine Cycles

PDF Source: development-radial-turbines-low-power-gas-turbine.pdf | Development of radial turbines in low power Gas turbine engines

PDF Source: energies-12-02791.pdf | Unidirectional Radial-Air-Turbine OWC Wave Energy Converters

PDF Source: energies-13-02118-v2.pdf | Off-Design Analysis of a Radial Outflow Turbine for ORC

PDF Source: ETC2017-039.pdf | LOSS GENERATION IN RADIAL OUTFLOW STEAM TURBINE CASCADES

PDF Source: Etd2.pdf | Gas Turbine Design Axial Flow Compressors

PDF Source: exergy-geothermal_start_up_october.pdf | Exergy installations go online in Turkey

PDF Source: exjobb_final_official_version_Erik_Svensson.pdf | A Detailed Analysis of Radial Turbines

PDF Source: fluid-dynamics-rot.pdf | FLUID-DYNAMICS OF THE ORC RADIAL OUTFLOW TURBINE

PDF Source: Geothermal_Resources_Council_2009_Poster.pdf | ORC Kalina Cycle Euler and Variable Pulse Turbine

PDF Source: Hummel_SMU-rot_2016.pdf | ORC Kalina Cycle Euler and Variable Pulse Turbine

PDF Source: ijtpp-05-00019.pdf | Optimal Design of a Ljungstrom Turbine for ORC Power

PDF Source: Ismail_Permana_2019_IOP_Conf94_012014.pdf | Turboexpander on Organic Rankine Cycle with Working Fluids

PDF Source: JAHS_Radial Flow.pdf | Radial Flow Rotating Blade Retreating Blade Stall

PDF Source: Laser_anemometer_measurements_of_the_three-d.pdf | Laser anemometer measurements of the three-dimensional rotor flow

PDF Source: Lec-35ppts.pdf | Turbomachinery Aerodynamics

PDF Source: nasa-rotor-67.pdf | Aerodynamic Design of the NASA Rotor 67 for Non Uniform Inflow

PDF Source: Optimised-Radial-Turbine-Design.pdf | Optimised Radial Turbine Design D1.8

PDF Source: orc-radial-turbine-truck-application.pdf | WHR on truck ORC radial inflow turbine integrated

PDF Source: PiechnaAkbariIancuMuellerIMECE2004-59022.pdf | RADIAL-FLOW WAVE ROTOR CONCEPTS, UNCONVENTIONAL DESIGNS

PDF Source: radial-turbine-unsteady-flows.pdf | Numerical computations of the unsteady flow in a radial turbine

PDF Source: ROT-vehicles.pdf | Off Hwy Vehicle Radial Turbine Expander Design WHR ORC

PDF Source: small-scale-radial-inflow-turbine-whr-orc.pdf | SMALL-SCALE RADIAL INFLOW TURBINE FOR WHR ORC

PDF Source: turbine-blade-aerodynamics.pdf | Turbine Blade Aerodynamics

PDF Source: Turbine-Options-Turbochargers NCB.pdf | HIGH BOOST TURBOCHARGERS radial and mixed flow turbines

PDF Source: turbine_selection_for_supercritical_co2_applications.pdf | turbine type for use in a super-critical CO2 power cycle

PDF Source: US3537802.pdf | turbine type for use in a super-critical CO2 power cycle

PDF Source: v001t01a041-72-gt-42.pdf | Recent Radial Turbine Research at Nasa Lewis 1972

PDF Source: v001t01a077-91-gt-220.pdf | Design and Testing of a Radial Flow Turbine for Aerodynamic Research

PDF Source: WorldOverview2017.pdf | World Overview of the Organic Rankine Cycle Market

PDF Source: ZD3562062.pdf | radial turbine supercritical compressed air energy storage

Email: greg@infinityturbine.com